Graham Jones, the owner of Hawks Hill Builders in Mechanicsville, Virginia,  knew this project was going to be a challenging build, but until he actually started he had no idea just how difficult the task was going to be. The building site was a steep slope adjacent to an existing home, with another dwelling not too far to the other side. Designed by architect Scott Stephens, the garage was going to be a three story structure, with storage on the lower floor, a three bay garage on the upper ground floor entrance level, and a large room on the top level to be used as an office, with two dormers on the front and a long single dormer on the rear. Due to the steep slope and the need to support the garage floor steel supports were going to be needed to uphold the building. This was definitely not the average residential garage, in scope, or in construction.

The front elevation of the finished garage.

The front elevation of the finished garage.

The rear elevation of the finished garage, and an indication of the steep slope of the the building site.

The rear elevation of the finished garage, and an indication of the steep slope of the the building site.

The 'before' photo, taken from the backside of the building site.

The ‘before’ photo, taken from the backside of the building site.

To get started two massive trees were cut down and the stumps removed, and then the excavation commenced. (All progress photos courtesy Graham Jones, Jr)

Giant stump

Giant stump

Some rock was encountered, which was not that big of a surprise. What was a surprise was that the encountered rock was almost one solid boulder, extending almost the entire length and width of the dig, and clearly not certain how deep. The project almost came to a halt.

Like an iceberg, only a small portion of the boulder is visible

Like a giant rock iceberg, only a small portion of the boulder is visible

However, the homeowner gave the go ahead to proceed, and proceeding meant blasting. Setting off dynamite in such close proximity to existing homes was not without its hazards. But with the help of highly trained explosives experts from Blasting Services of Rockville, Virginia, the massive boulder was slowly broken into manageable chunks.

After the dynamite -1

After the dynamite -1

These boulders were then used to shore up the new grade elevation at the bottom of the slope. Once excavation was complete, the garage proceeded to go up as originally planned. There were problems encountered, but none as big, literally or figuratively, as the enormous rock formation that nearly stopped this project before it got started.

Note the close proximity of the existing home. Not the ideal place to setting off dynamite!

Note the close proximity of the existing homes. Not the ideal place for setting off dynamite!

As seen in the above image, the rear yard was raised some 4 to 6 feet, anchored in place by the boulders blasted out of the garage site.

It took a huge amount of steel to not only anchor the building, but hold up the garage floor, the weight of three vehicles, plus the remainder of the building.

Steel beams support the weight of the building.

Huge steel beams support the weight of the building.

The steel beams are installed

The steel beams are installed

Of the three garage bays, the far left bay doubles as a wash station. A fully functioning, restored antique air pump fits in nicely in the back corner of the wash bay.

Wash Bay

The top floor, the office, is one big room with a fireplace at one end, and the stairwell, half bath, and cabinetry at the other. The front of the room has two dormers, while the rear has one long continuous dormer.

Fireplace

Fireplace

Stairwell wall, with cabinetry and half  bath

Stairwell wall, with cabinetry and half bath

Hawks Hill Builders, LLC, R. Graham Jones, Jr., Owner, 7029 Hawks Hill Lane, Mechanicsville, VA 23111 hawkshillbld@comcast.net

Click on any image below to take you to a slideshow of big images. Thanks for looking! Please leave comments, I’m interested to hear what you have to say!

Advertisements

3 Responses to “A Rocky Start to a Garage Build”

  1. Nevin Kishbaugh

    John, very nice work, as usual. You were very fortunate, as are we, the readers, that you had access to the site before, during and after construction. It provides a real sense of continuity, as well as a sense of what was created. You not only understand the issues relating to the design aspects, but your images convey them nicely.

    Reply
  2. Benita Miller

    Wow! What a really cool garage!! The exterior architecture coordinates beautifully with the existing home, and all the special details make it charming and unique. How great to have a wash station inside the garage! Love the upstairs room/office – so light and bright and tasteful – That’s an office you could spend lots of time in and be very happy. Makes me wonder what we can do with our garage!

    Reply

Leave a Reply

Fill in your details below or click an icon to log in:

WordPress.com Logo

You are commenting using your WordPress.com account. Log Out / Change )

Twitter picture

You are commenting using your Twitter account. Log Out / Change )

Facebook photo

You are commenting using your Facebook account. Log Out / Change )

Google+ photo

You are commenting using your Google+ account. Log Out / Change )

Connecting to %s

Basic HTML is allowed. Your email address will not be published.

Subscribe to this comment feed via RSS

%d bloggers like this: